Phase 2
transmission needs external radiator and will rebuilt it too
we removed the oil pan to replace gasket due to a leak and found tranny needs to be rebuilt
see the sludge in oil pan mixed with metal shavings, also the new radiator for the tranny will be installed
radio done! scary amount of wires huh?
all gauges out, alarm being installed...
alarm being set up
AND MORE WORK, REPAIR GAUGES, ALL LIGHTS WERE BURNED, PRINTED CIRCUIT FIXED, ETC...
oil filter housing had no gasket,
hard to remove with engine in place
tranny rebuilt and installed
rear brakes being adjusted, rotors will be cut and reinstalled
instaling brackets for A/c (HARD TO FIND )
new compressor
we are rebuilding carb
door panels being installed! 5/31/2007
this is the tank I have as you can see shorter neck
right now is too long
also had to get a pair of wiper arms since car had none see below, no arms, will updload more pics tomorrow
finally new compressor hooked, new brackets, new lines
Carburator done
Our head mechanic Carlos re installing the rebuilt carb
driver side door panel done
passenger side door panel done
Final buff in order to deliver clean and shinny
Clean and detailed, almost done
Got the brackets from Brett! we stripped them and refinished
installed! as you can see new caliper too!
gone!
new tank we had to install, could not make work the old one
we removed housing and replaced thermostat, and replaced fuel line with brand new one
replaced the front tank with a new holly part
new fuel bowl
I am pointing at the pump that was just removed (no bird this time)
POWER STEERING PUMP ALSO HAD TO REPLACE.../yes was bad, leaking
finally!
took it out for a spin, still have to adjust some stuff, vacuum lines, but runs good and feels very powerful, still needs to break in engine, shoud be taking it to muffler shop to install the dual exhaust and splitters tomorrow.
This car came with high performance set up shaker had to be be attahed to the hood
wiper arms installed and new blades
apply all missing decals here and there
dual splitters will be installed with the new exhaust
well, tested car again with A/C before taking it to muffler shop....guess what fan clutch no blowing enough, temp went up, fortunately I had a new one in my shelf and replaced it
had also a leak on the under dash ducts, sealed and installed along new vent
it runs!!!!!!!!!!! to mufflers shop (car has your name on the windshield)
I ordered to get rid of those temporary pipes pipes it had and install new muffler from headers down to rear splitters
NEW TIPS
NEW PIPES AND NEW FLOW MASTER MUFFLERS
COMPLETION PHOTOS TONIGHT (IF IS NOT RAINING AGAIN TODAY)
*recreation
TO BE CONTINUED....
click below to go to: